Wiring Your Gas Golf Cart Solenoid: What You Need to Know - The Brassie (2024)

The E-Z-GO Gas Golf Cart is a popular choice for golf enthusiasts and those who enjoy outdoor activities. With its reliable engine and sturdy construction, this golf cart is designed to provide years of enjoyment. However, like any mechanical device, there may come a time when certain components need to be replaced or repaired. One such component is the solenoid, which plays a crucial role in the operation of the golf cart.

The solenoid is responsible for controlling the flow of electrical current to various parts of the golf cart, such as the ignition system and the switch that activates the cart. It acts as a switch, allowing or blocking the flow of electricity depending on the position of the ignition key. When the key is turned on, the solenoid is activated and allows electricity to flow, starting the engine and powering the cart.

When it comes to wiring the solenoid, it is important to ensure that the wires are connected correctly. In most cases, the order of the wires does not matter. However, there are instances when it is crucial to connect the wires in the correct order. For example, if the solenoid is controlling a switch, it is important to make sure that the load wire is connected to the correct terminal. If the wires are connected incorrectly, the circuit may not work properly, and the golf cart may not start or function as intended.

To check if the solenoid is functioning properly, you can perform a simple voltage test. Place the positive probe of a voltmeter to the controller side of the solenoid’s large post. The reading should be approximately 0.1 to 3 volts less than the battery voltage. If the reading is more than 3 volts less than the battery voltage, it indicates a faulty resistor. On the other hand, if the voltage reading is the same as the battery voltage, it is a sign that the solenoid needs to be replaced.

Another way to test the solenoid is by listening for a clicking sound when you step on the gas pedal. The solenoid should make a clicking sound, indicating that it is activating and allowing electricity to flow. Additionally, you can use a multimeter to measure the resistance of the solenoid. A functioning solenoid should have a reading of less than 0.4 ohms. If the reading is higher, it indicates that the solenoid is not working properly and needs to be replaced.

One of the most obvious signs of solenoid failure is when the golf cart fails to turn on when you turn the key. Normally, the solenoid clicks a little with the ignition system in regular operation. However, if the solenoid is failing, it may not make any sound when you turn the key, indicating a problem with its functioning.

The solenoid is an important component of the E-Z-GO Gas Golf Cart, responsible for controlling the flow of electrical current to various parts of the cart. It is crucial to ensure that the solenoid is wired correctly, as incorrect wiring can lead to malfunctions in the cart’s electrical system. Performing voltage and resistance tests can help determine if the solenoid is functioning properly. If signs of solenoid failure, such as a lack of clicking sound or failure to start the cart, are present, it may be necessary to replace the solenoid. Regular maintenance and proper wiring can help ensure the smooth operation of your E-Z-GO Gas Golf Cart.

Does It Matter Which Way A Solenoid Is Wired?

When it comes to wiring a solenoid, in most cases, it doesn’t really matter which way the wires are connected. The solenoid is an electromagnetic device that converts electrical energy into mechanical motion. It typically consists of a coil of wire wrapped around a metal core, and when an electric current flows through the coil, it creates a magnetic field that attracts or repels the core.

In general, the solenoid will function properly regardless of the wire order. However, there are a few situations where the wiring order does matter. Let’s take a closer look:

1. Controlling a switch: If the solenoid is being used to control a switch or relay, it is crucial to ensure that the load wire is connected to the correct terminal. This is because the solenoid’s magnetic field will actuate the switch, and if the load wire is connected to the wrong terminal, the circuit may not work as intended.

2. Polarity-sensitive applications: Some solenoids, especially those used in more specialized applications, may be polarity-sensitive. This means that they require a specific voltage polarity to function correctly. In such cases, it is important to follow the manufacturer’s instructions and connect the positive and negative terminals accordingly.

While the order of the wires may not be critical in most solenoid applications, it is still good practice to follow any provided instructions or guidelines. This ensures proper functionality and avoids any potential issues that may arise from incorrect wiring.

To summarize, when wiring a solenoid, it usually doesn’t matter which wire goes where. However, in situations where the solenoid is controlling a switch or if it is polarity-sensitive, it becomes essential to pay attention to the wire order to ensure proper operation.

How Do You Test The Solenoid On A Ezgo Gas Golf Cart?

To test the solenoid on an EZGO gas golf cart, follow these steps:

1. Begin by locating the solenoid on the cart. It is typically found near the battery compartment or the engine.

2. Disconnect the negative terminal of the battery to ensure safety during the testing process.

3. Identify the large posts on the solenoid. One side is connected to the battery, and the other side is connected to the controller.

4. Take the positive probe of a voltmeter and place it on the controller side of the solenoid’s large post.

5. With the negative probe of the voltmeter grounded, turn on the ignition key or press the accelerator pedal to activate the cart’s electrical system.

6. Observe the voltmeter reading. It should be approximately 0.1 to 3 volts less than the battery voltage.

7. If the reading on the voltmeter is more than 3 volts less than the battery voltage, it indicates a faulty resistor. In this case, the resistor will need to be replaced.

8. On the other hand, if the voltmeter reading is the same as the battery voltage, it suggests a problem with the solenoid itself. In such a situation, the solenoid should be replaced.

Note: It’s crucial to follow proper safety precautions while conducting any electrical testing. If you are unsure or uncomfortable with performing these steps, it is recommended to consult a professional technician for assistance.

How Do I Know If My Gas Golf Cart Solenoid Is Bad?

To determine if your gas golf cart solenoid is bad, you can follow these steps:

1. Step on the gas: Start by pressing down on the gas pedal of your golf cart.

2. Listen for clicking sound: While pressing the gas pedal, pay attention to any clicking sound coming from the solenoid. The solenoid is responsible for controlling the flow of electricity to the starter generator, and a clicking sound typically indicates that it is working.

3. Check resistance reading: If you hear the clicking sound, you can further test the solenoid by using a multimeter to measure its resistance. Set the multimeter to the ohms (Ω) setting.

4. Connect multimeter: Connect the multimeter’s probes to the two terminals of the solenoid. The positive probe should be connected to the terminal with the smaller wire, while the negative probe should be connected to the terminal with the larger wire.

5. Read resistance: Once the multimeter is properly connected, read the resistance displayed on the screen. A reading of fewer than 0.4 ohms indicates that the solenoid is functioning correctly.

6. Replace if necessary: If the resistance reading is higher than 0.4 ohms, it indicates that the solenoid is not working properly and may need to be replaced.

In summary, to determine if your gas golf cart solenoid is bad, listen for a clicking sound while pressing the gas pedal and check for a resistance reading of fewer than 0.4 ohms using a multimeter. If the solenoid does not click or the resistance reading is higher, it may need to be replaced.

What Are The Symptoms Of A Bad Solenoid On An Ezgo Golf Cart?

Symptoms of a bad solenoid on an EZGO golf cart can manifest in various ways. Here are some key indicators to look out for:

1. Failure to Start: When you turn the key to start the golf cart and nothing happens, it is often a sign of a faulty solenoid. The solenoid is responsible for transferring electrical current from the battery to the starter motor, enabling the engine to start. If the solenoid is bad, it may not engage or complete the circuit, preventing the cart from starting.

2. Clicking Sound: When you turn the key, you may hear a clicking sound coming from the solenoid. This clicking noise indicates that the solenoid is receiving power, but it might not be transferring it effectively. In some cases, the solenoid may click repeatedly without engaging, preventing the cart from starting.

3. Intermittent Starting Issues: A failing solenoid may cause intermittent starting problems. Sometimes, the golf cart may start without any issues, while other times it may fail to start. This inconsistency can be a result of a faulty solenoid that is not consistently engaging or completing the electrical circuit.

4. Slow or Weak Start: If the solenoid is not functioning properly, it may not transfer enough power to the starter motor. This can result in slow or weak starts, where the engine cranks slowly or struggles to turn over. If you notice a decrease in starting power, it could be due to a bad solenoid.

5. Smoke or Burning Smell: In more severe cases, a bad solenoid may cause electrical problems that lead to smoke or a burning smell. This can occur if the solenoid is damaged or shorted, causing excessive heat or electrical arcing. If you detect any smoke or burning odor, it is crucial to address the solenoid issue immediately to prevent further damage or potential safety hazards.

It is important to note that while these symptoms are common indicators of a bad solenoid, they can also be signs of other electrical or mechanical issues in the golf cart. If you experience any of these symptoms, it is recommended to consult a professional or have a qualified technician inspect and diagnose the problem to ensure an accurate and effective repair.

Conclusion

The solenoid in an E-Z-GO gas golf cart plays a crucial role in the operation of the ignition system and other electrical components. It is responsible for controlling the flow of electricity and ensuring that the cart functions properly.

When troubleshooting solenoid issues, it is important to check the voltage readings to ensure that they are within the correct range. If the readings are significantly lower or higher than expected, this could indicate a faulty resistor or a malfunctioning solenoid.

Another sign of solenoid failure is the lack of response when turning the key to start the golf cart. If the solenoid is not working properly, it may not click as it should, and the cart will fail to turn on.

In such cases, it is advisable to replace the solenoid to restore the proper functioning of the golf cart. It is always best to consult a professional or refer to the manufacturer’s guidelines for specific instructions on replacing the solenoid.

By being attentive to these signs and taking appropriate action, you can ensure that your E-Z-GO gas golf cart remains in optimal condition and continues to provide reliable performance on the course.

Wiring Your Gas Golf Cart Solenoid: What You Need to Know - The Brassie (2024)

References

Top Articles
Latest Posts
Article information

Author: Geoffrey Lueilwitz

Last Updated:

Views: 5853

Rating: 5 / 5 (80 voted)

Reviews: 87% of readers found this page helpful

Author information

Name: Geoffrey Lueilwitz

Birthday: 1997-03-23

Address: 74183 Thomas Course, Port Micheal, OK 55446-1529

Phone: +13408645881558

Job: Global Representative

Hobby: Sailing, Vehicle restoration, Rowing, Ghost hunting, Scrapbooking, Rugby, Board sports

Introduction: My name is Geoffrey Lueilwitz, I am a zealous, encouraging, sparkling, enchanting, graceful, faithful, nice person who loves writing and wants to share my knowledge and understanding with you.